Chart 2
WARNING: This page does not describe the selected car, but rather 9 other vehicles, including the 2005 Ford RV Cutaway, 2005 Ford Pickup, 2005 Ford F550 Super Duty, 2005 Ford F450 Super Duty, and 2005 Ford Excursion. However, it is still accessible from the selected car via links, so may be relevant.
- Stalls/Quits: Idle, Acceleration, Cruise, Deceleration
Carry out the following preliminary checks:
- Engine for correct oil level/quality.
- Electrical connections.
- Automatic transmission - torque converter operation, always applied.
- Automatic transmission fluid (ATF) level.
- Engine overheating.
| SYSTEM/COMPONENT | REFERENCE ( PINPOINT TESTS - 6.0L DIESEL unless noted) |
|---|---|
| Check For Cold Weather Stall | If the engine restarts after a stall, the oil return to the oil pan may be too slow. CONFIRM the correct grade of oil for frigid conditions. CHANGE the oil if necessary. |
| Check Performance Diagnostics | CARRY OUT the PERFORMANCE DIAGNOSTIC PROCEDURES . |
| Check Torque Converter Operation If Stalls at Idle | REFER to AUTOMATIC TRANSAXLE/TRANSMISSION . |
| Check Air Intake System | Visually INSPECT the air inlet for obstructions/restrictions. REPAIR as necessary. RESET the air filter restriction gauge. |
| Check Reference Voltage (VREF) | GO to Pinpoint Test B . |
| CHECK RPM Signal | CARRY OUT the CHECK THE RPM SIGNAL WHILE CRANKING Test. |