LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 1996 >> Aerostar Van Window >> Repair and Diagnosis >> External Pages >> Different car >> Section 220 (Engine Controls - System & Component Tests - 7.3L Diesel) >> Hard Start/No-Start Diagnosis >> Check Engine Oil >> Diagnostic Aids

Diagnostic Aids

WARNING: This page does not describe the selected car, but rather 16 other vehicles, including the 1996 Ford RV Cutaway, 1996 Ford Pickup, 1996 Ford F-Super Duty, 1996 Ford Econoline, and 1996 Ford Cutaway. However, it is still accessible from the selected car via links, so may be relevant.

Checking engine oil helps determine if there is enough engine oil to operate fuel injectors. If there is little or no oil in crankcase, injectors will not operate.

  1. Ensure vehicle is on level ground. Check engine oil. If oil is overfilled, engine may have been incorrectly serviced, or fuel is diluted with engine oil and filling crankcase. Repair as necessary.
  2. Inspect oil color. A milky White color indicates possible coolant contamination. Determine cause and repair as necessary. If oil level is low, top off oil. Ensure oil is correct type and viscosity.
  3. Remove plug in top of oil reservoir and check oil level. If oil level is within 1" (25.4 mm) of fill hole, level is okay. If oil level is not within 1" (25.4 mm) of fill hole, top off fluid. Attempt to start vehicle. If vehicle starts, determine cause of low oil level and repair as necessary.
scientia non olet · About LEMON Manuals