Diagnostic Aids
WARNING: This page does not describe the selected car, but rather 7 other vehicles, including the 1995 Ford RV Cutaway, 1995 Ford Pickup, 1995 Ford F-Super Duty, 1995 Ford Econoline, and 1995 Ford Cutaway. However, it is still accessible from the selected car via links, so may be relevant.
To prevent replacing good components, be aware the following non-EEC related areas may be cause of problem:
- Technician did not perform brief Wide Open Throttle (WOT) after Dynamic Response Code.
- Engine did not go over 2000 RPM during WOT. This test is only intended to diagnose:
- Throttle movement (minimum 3/4 throttle).
- RPM increase is more than 2000 RPM.
If throttle is snapped open briefly, it may not pass WOT test. Ensure throttle is depressed fully to WOT and engine speed exceeds 2000 RPM.
Code 538: System Failed To Recognize WOT Test
Repeat KOER SELF-TEST as follows:
- Activate SELF-TEST.
- Start engine.
- Observe ID Code start of test.
- Observe Dynamic Response Code 1 (Code 0 with Star tester).
- Perform brief WOT.
- Testing is complete; Diagnostic Test Code (DTC) output begins.
Ensure vehicle speed reached 2000 RPM during WOT. If Code 538 is present, replace PCM. If Code 538 is not present, vehicle has passed dynamic response test. Service other codes if necessary.