Brake Shoes &/Or Pads: Remove & Replace
WARNING: This page is about the Explorer 2D Utility, 4WD, Automatic, which is a different variant/trim than selected.
Includes: Clean, lube and/or replace Brake Hardware as necessary. Adjust Brakes (where applicable).
Includes: Repack Wheel Bearings (where applicable).
DOES NOT include refinishing.| Applies To | Note | Standard Hours | Warranty Hours | Skill Level |
|---|---|---|---|---|
| All,Both Axles,w/Rear Disc Brakes | 1.8 | B | ||
| All,Both Axles,w/Rear Drum Brakes | 2.2 | B | ||
| Front,Both Sides | 1.0 | B | ||
| Rear,Both Sides,Drum Brakes | 1.4 | B | ||
| Rear,Both Sides,w/Rear Disc Brakes | 1.0 | B | ||
| Combination Procedure: AXLE SEAL: Replace: Semi-Floating Axle. | ||||
| Rear,Both,w/Limited Slip | 1.3 | B | ||
| Rear,Both,w/o Limited Slip | 1.2 | B | ||
| Rear,One Side,w/Limited Slip | 1.1 | B | ||
| Rear,One Side,w/o Limited Slip | 1.0 | B | ||
| Combination Procedure: BRAKE HOSE: Replace: Includes: Bleed Brake System. | ||||
| Each Additional | 0.2 | B | ||
| One | 0.4 | B | ||
| Combination Procedure: CALIPER: Overhaul: | ||||
| One,Single Piston | Includes: Bleed Brakes. | 0.5 | B | |
| Combination Procedure: CALIPER: Replace: | ||||
| One | Includes: Bleed Brakes. | 0.3 | B | |
| Combination Procedure: DISC ROTOR: Burnish Brake Rotors While Driving Vehicle: | ||||
| 0.5 | B | |||
| Combination Procedure: DISC ROTOR: Remove and Install for Refinishing: NOTE: This operation does not apply to drive axles. If on vehicle refinishing is not possible use appropriate repair operation. | ||||
| 4WD, Each,Front | Includes: Repack Wheel Bearings. | 0.6 | B | |
| Combination Procedure: DISC ROTOR: Replace: | ||||
| 4WD, Each,Front | Includes: Repack Wheel Bearings. | 0.7 | B | |
| Combination Procedure: DRUM: Replace: | ||||
| Each | 0.1 | B | ||
| Combination Procedure: WHEEL BEARING: Repack: | ||||
| 4WD, Front,Both Sides | 1.4 | B | ||
| Combination Procedure: WHEEL BEARING: Replace: | ||||
| 4WD, Front,One Side,Non Separable | 0.8 | B | ||
| Rear,Both,w/Limited Slip | 1.9 | B | ||
| Rear,Both,w/o Limited Slip | 1.8 | B | ||
| Rear,One Side,w/Limited Slip | 1.4 | B | ||
| Rear,One Side,w/o Limited Slip | 1.3 | B | ||
| Combination Procedure: WHEEL CYLINDER: Overhaul: | ||||
| Off Vehicle,One | Includes: Bleed Brakes. | 0.5 | B | |
| On Vehicle,One | Includes: Bleed Brakes. | 0.3 | B | |
| Combination Procedure: WHEEL CYLINDER: Replace: | ||||
| One | Includes: Bleed Brakes. | 0.5 | B | |