LEMON Manuals: Even more car manuals for everyone
Home >> Eagle >> 1994 >> Talon ES, Automatic >> Repair and Diagnosis (Single Page) >> Engine Mechanical >> Mechanical >> 2.0L 4-CYL - VIN [E] >> Removal & Installation >> Oil Pan >> Removal (4WD)

Removal (4WD)

  1. Drain engine oil. Remove crossmember near transaxle end of oil pan. Transfer case assembly must be removed. Disconnect exhaust pipe at exhaust manifold. Remove transfer case-to-transaxle bolts.
  2. Move transfer case left, and lower front side. Disengage transfer case from drive shaft, being careful not to damage transfer case oil seal. Tie drive shaft aside to prevent excessive angle on shaft.
  3. Remove left axle shaft and inner shaft assembly. See information in AXLE SHAFTS - FRONT article in DRIVE AXLES.
  4. Remove oil pan bolts. Install Oil Pan Remover (MD998727) between oil pan and cylinder block to break sealant from cylinder block. Remove oil pan. Clean sealant from block and oil pan.
scientia non olet · About LEMON Manuals