LEMON Manuals: Even more car manuals for everyone
Home >> Dodge and Ram >> 2003 >> Durango Base, 5.9 Z, RWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 106 (Chassis Diagnostic Procedures - Anti-Lock Brake System) >> Diagnostic Information And Procedures >> Brakes (Cab) - Symptoms >> Symptom: TIRE REVS PER MILE OUT OF RANGE - 83 >> Possible Causes

Possible Causes

WARNING: This page is about a different car, the 2004 Dodge Dakota. However, it is still accessible from the selected car via links, so may be relevant.
  1. INCORRECT TIRES PROGRAMMED INTO CAB
  2. INTERMITTENT DTC
  3. CAB INTERNAL FAULT
TEST ACTION AND APPLICABILITY

TEST ACTION APPLICABILITY
1 Turn the ignition on.
Observe the ABS Warning Indicator.
Is the ABS Warning Indicator Flashing?
  1. Yes --> Go To 2
  2. No --> Go To 3
 All
2 Inspect all four of the tire sizes on the vehicle.
NOTE: Non-production size tire cannot be programmed into the CAB. The production Powertrain, with the production size tires is the only emissions certified configuration that is available for reprogramming.

Turn the ignition on.
With the DRBIII®, read the tire size that is programmed into the CAB.
Does the DRBIII® displayed tire size match the actual tire size on the vehicle?
  1. Yes --> Replace the Controller Antilock Brake in accordance with the Service Information. Refer to the SYMPTOM: *REPLACING THE CONTROLLER ANTILOCK BRAKE  for additional information.

    Perform ABS VERIFICATION TEST - VER 1.

  2. No --> Reprogram the tire size. Make sure that the ignition is on throughout the entire reprogramming procedure.

    Perform ABS VERIFICATION TEST - VER 1.

 All
3 Turn the ignition off.
Visually inspect the related wiring harness. Look for any chafed, pierced, pinched, or partially broken wires.
Visually inspect the related wire harness connectors. Look for broken, bent, pushed out, or corroded terminals.
Refer to any Hotline letters or Technical Service Bulletins that may apply.
Were any problems found?
  1. Yes --> Repair as necessary.

    Perform ABS VERIFICATION TEST - VER 1.

  2. No --> Test Complete.
 All
scientia non olet · About LEMON Manuals