Section 5 (6.1L Engine (Service Information)): Specifications: Torque
WARNING: This page is about a different variant/trim than selected.
6.1L ENGINE
| DESCRIPTION | N.m | Ft. Lbs. | In. Lbs. |
|---|---|---|---|
| Block Pipe Plugs | - | ||
| (1/4 NPT) | 20 | 15 | - |
| (3/8 NPT) | 27 | 20 | - |
| Camshaft Sprocket - Bolt | 122 | 90 | - |
| Camshaft Tensioner Plate - Bolts | 28 | 21 | - |
| Timing Chain Case Cover - Bolts | 28 | 21 | - |
| Lifting Stud | 55 | 40 | - |
| Connecting Rod Cap - Bolts | 45 plus 60° Turn |
33 plus 60° Turn |
- |
| Main Bearing Cap - Bolts | - | ||
| M-12 Bolts | 28 plus 90° Turn |
21 plus 90° Turn |
- |
| Crossbolts M-8 Bolts |
22 | 16 | - |
| Cylinder Head - Bolts
NOTE:
Follow Installation sequence. See Engine/Cylinder Head - Installation .
|
- | ||
| M-12 Bolts | |||
| Step 1 - Tighten bolts 1-10 Step 1 - Tighten bolts 11-15 |
34 20 |
25 15 |
- |
| Step 2 - Tighten bolts 1-1 0 Step 2 - Tighten bolts 11-1 5 verify |
54 20 |
40 15 |
- |
| Step 3 - Rotate bolts 1-10 | 90° | - | - |
| Step 4 - Tighten bolts 11-15 | 34 | 25 | - |
| Cylinder Head Cover - Bolts | 8 | - | 70 |
| Exhaust Manifold to Cylinder Head - Bolts | 31 | 23 | - |
| Flexplate to Crankshaft - Bolts | 95 | 70 | - |
| Flywheel to Crankshaft - Bolts | 75 | 55 | - |
| Front Insulator - Through bolt/nut | 95 | 70 | - |
| Front Insulator to Block - Bolts | 95 | 70 | - |
| Generator - Mounting Bolt | 55 | 40 | - |
| Intake Manifold - Bolts
NOTE:
Follow Installation sequence. See Engine/Manifolds/MANIFOLD, Intake - Installation
|
12 | 9 | 106 |
| Lifter Guide Holder | 12 | 9 | 106 |
| Piston Oil Cooler Jet - Bolts | 13 | 10 | 115 |
| Oil Pan - Bolts | 12 | 9 | 105 |
| Oil Dipstick Tube | 31 | 23 | - |
| Oil Pan - Drain Plug | 27 | 20 | - |
| Oil Pump - Attaching Bolts | 28 | 21 | - |
| Oil Pump Pickup Tube - Bolt and Nut | 28 | 21 | - |
| Rear Seal Retainer Attaching Bolts | 15 | 11 | - |
| Rear Insulator to Bracket | 68 | 50 | - |
| Rear Insulator to Crossmember | 41 | 30 | - |
| Rear Insulator to Transmission | 68 | 50 | - |
| Rear Insulator Bracket - Bolts | 68 | 50 | - |
| Rocker Arm - Bolts | 22 | 16 | - |
| Thermostat Housing - Bolts | 28 | 21 | - |
| Throttle Body - Bolts | 12 | 9 | 105 |
| Vibration Damper - Bolt | 176 | 129 | - |
| Water Pump to Timing Chain Case Cover - Bolts | 28 | 21 | - |