LEMON Manuals: Even more car manuals for everyone
Home >> Chrysler >> 2009 >> 300 Signature Series >> Repair and Diagnosis >> External Pages >> Different car >> Section 114 (Interior & Exterior (2 Of 2)) >> Interior >> Headliner >> Removal >> Removal - Coupe

Removal - Coupe

WARNING: This page is about a different car, the 2006 Chrysler PT Cruiser. However, it is still accessible from the selected car via links, so may be relevant.
Fig 1: Headliner With Sun Roof - Typical
GC0022413Courtesy of DAIMLERCHRYSLER CORP.
  1. Fully recline front seats and fold rear seats forward.
  2. Remove screws attaching sun visors (2) to roof header panel.
  3. Disconnect wire connector from lighted vanity mirror, if so equipped.
  4. Remove trim lace, if equipped with sun roof.
  5. Remove sun visors (2) from vehicle.
  6. Remove A-pillar trim covers.
  7. Remove B-pillar trim panels.
  8. Remove C-pillar and D-pillar trim panels.
  9. Remove assist handle, if so equipped.
  10. Remove sun visor hooks.
  11. Remove coat hooks, if so equipped.
  12. Remove two push in fasteners at rear of headliner.
  13. Disengage wire connector, at base of A-pillar.
  14. Remove push in fastener attaching wiring to A-pillar.
  15. Remove headliner through rear hatch.
scientia non olet · About LEMON Manuals