Heating-A/C System
WARNING: This page is about a different car, the 2005 Dodge Stratus and 2005 Chrysler Sebring. However, it is still accessible from the selected car via links, so may be relevant.
A/C SYSTEM - 2.7L/2.4L NA
| Item | Description | Notes |
|---|---|---|
| A/C Compressor | Visteon HS-15 (piston type) | VC-46 PAG oil |
| Freeze-up Control | Evaporator temperature sensor | A/C evaporator mounted |
| Low psi Control | A/C pressure transducer | Discharge line mounted |
| High psi Control | ||
| Refrigerant Charge Capacity | Refer to A/C Underhood Specification Label located in the engine compartment | R-134a refrigerant |
| A/C Clutch Current Draw | 2 - 4 amps | @ 12V +/- 0.5V @ 21° C (70° F) |
| A/C Clutch Air Gap | 0.35 - 0.75 mm (0.014 - 0.030 in.) | - |
A/C SYSTEM - 2.0L/2.4L TURBO
| Item | Description | Notes |
|---|---|---|
| A/C Compressor | Sanden TRS-090 (scroll type) | SP-15 PAG oil |
| Freeze-up Control | Evaporator temperature sensor | A/C evaporator mounted |
| Low psi Control | A/C pressure transducer | Discharge line mounted |
| High psi Control | ||
| Refrigerant Charge Capacity | Refer to A/C Underhood Specification Label located in the engine compartment | R-134a refrigerant |
| A/C Clutch Current Draw | 2 - 4.15 amps | @ 12 V +/- 0.5V @ 21° C (70° F) |
| A/C Clutch Air Gap | 0.33 - 0.63 mm (0.013 - 0.025 in.) |
FASTENER TORQUE
| Description | N.m | Ft. Lbs. | In. Lbs. |
|---|---|---|---|
| All Screws NOT Listed Below | 2 | - | 17 |
| A/C Compressor Shaft Bolt (2.4L NA/2.7L) | 13 | - | 115 |
| A/C Compressor Shaft Nut (2.0L/2.4L Turbo) | 17.5 | - | 155 |
| A/C Compressor Manifold Bolts (2.4L NA/2.7L) | 22 | 16 | - |
| A/C Compressor Mounting Bolts (2.4L NA/2.7L) | 28 | 20 | - |
| A/C Compressor Mounting Bolts (2.0L/2.4L Turbo) | 28 | 20 | - |
| A/C Condenser Bolts | 5 | - | 45 |
| A/C Expansion Valve Bolts | 8 | - | 71 |
| Auto Transaxle Cooler Lines to Condenser Nuts | 18 | 13 | - |
| Discharge Line to Compressor Bolt | 22 | 16 | - |
| Discharge Line to Condenser Bolt | 22 | 16 | - |
| Liquid Line to Condenser Bolt (2.0L/2.4L NA/2.7L) | 22 | 16 | - |
| Refrigerant Lines to Expansion Valve Nut | 8 | - | 71 |
| Suction Line to Compressor Bolt | 22 | 16 | - |