LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2023 >> Camaro ZL1, 2D Convertible, Standard Trans >> Repair and Diagnosis >> Heating, Ventilation & A/C (HVAC) >> HVAC Control Systems >> Heating, Ventilation, And Air Conditioning >> Specifications >> Approximate Fluid Capacities

Approximate Fluid Capacities

Refrigerant System Capacities with LGX

Application Specification
Metric English
PAG Oil Capacities
Loss of PAG Oil on an Abrupt Refrigerant Loss 24 ml1 0.8 oz1
Any Line Set (Hose/Tube or Tube Assembly) Replacement 12 ml2 0.4 oz2
NOTE:

Compressor failure can occur if the oil removed during refrigerant recovery is not replaced.

The service compressors are shipped with 41 ml2 (1.4 oz2 ) of PAG oil. Refer to the oil balance instructions for information regarding the specific service compressor oil charge. Air Conditioning Compressor Oil Balancing 
Compressor Replacement 41 ml2 1.4 oz2
Condenser Replacement 24 ml2 0.8 oz2
Desiccant Cartridge 4 ml2 0.1 oz2
Evaporator Replacement 24 ml2 0.8 oz2
  • Total System PAG Oil Capacity
 80 ml 2.7 oz
Refrigerant Charge R-134a
  • Air Conditioning System
 .55 kg 1.2 lb
Refrigerant Charge R - 1234yf
  • Air Conditioning System
 .50 kg3 1.1 lb3
1 Abrupt refrigerant loss due to large leak, hose rupture, collision, or pressure relief valve opening. Conditions that allow the refrigerant to seep or bleed off over time do not cause large amount of PAG oil loss. Upon replacement of a component that caused a large refrigerant loss, add the required amount of PAG oil for the particular component.
2 If more than the specified amount of PAG oil was drained from a component, add the amount drained.
3 This vehicle has a refrigerant charge operational tolerance of -.07 kg to +.03 kg/- 0.154 lbs to + 0.066 lbs. If refrigerant charge falls outside of this range, please refer to Air Conditioning (A/C) System Performance Test.
Refrigerant System Capacities with LTG, LT1, LT4

Application Specification
Metric English
PAG Oil Capacities
Loss of PAG Oil on an Abrupt Refrigerant Loss 36 ml1 1.2 oz1
Any Line Set (Hose/Tube or Tube Assembly) Replacement 18 ml2 .6 oz2
NOTE:

Compressor failure can occur if the oil removed during refrigerant recovery is not replaced.

The service compressors are shipped with 41 ml2 (1.4 oz2 ) of PAG oil. Refer to the oil balance instructions for information regarding the specific service compressor oil charge. Air Conditioning Compressor Oil Balancing 
Compressor Replacement 41 ml2 1.4 oz2
Condenser Replacement 36 ml2 1.2 oz2
Desiccant Cartridge 6 ml2 0.2 oz2
Evaporator Replacement 36 ml2 1.2 oz2
  • Total System PAG Oil Capacity
 120 ml 4.0 oz
Refrigerant Charge R-134a
  • Air Conditioning System (LTG)
 .55 kg 1.2 lb
  • Air Conditioning System (LT1, LT4)
 .50 kg 1.1 lb
Refrigerant Charge R - 1234yf
  • Air Conditioning System (Except Europe LTG)
 .55 kg3 1.2 lb3
  • Air Conditioning System (Except Europe LT1, LT4)
 .50 kg3 1.1 lb3
1 Abrupt refrigerant loss due to large leak, hose rupture, collision, or pressure relief valve opening. Conditions that allow the refrigerant to seep or bleed off over time do not cause large amount of PAG oil loss. Upon replacement of a component that caused a large refrigerant loss, add the required amount of PAG oil for the particular component.
2 If more than the specified amount of PAG oil was drained from a component, add the amount drained.
3 This vehicle has a refrigerant charge operational tolerance of -.07 kg to +.03 kg/- 0.154 lbs to + 0.066 lbs. If refrigerant charge falls outside of this range, please refer to Air Conditioning (A/C) System Performance Test.
scientia non olet · About LEMON Manuals