LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2023 >> Camaro ZL1, 2D Convertible, Standard Trans >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 23 (Engine Controls And Fuel - 3.6L - Diagnostic Information And Procedures (2 Of 2)) >> Diagnostic Information and Procedures >> Fuel System Diagnosis (NPP) >> Circuit/System Testing

Circuit/System Testing

WARNING: This page is about a different variant/trim than selected.

Fuel Pressure Low

  1. Verify none of the conditions listed below exist:
    • Restricted fuel feed pipe
    • Restricted or plugged strainer
    • Inspect the harness connectors and the ground circuits of the fuel pump for poor connections.
    • If a condition exist 

      Repair as necessary.

    • Go to next step: If a condition does not exist 
  2. Test or replace the G12 Fuel Pump.

Fuel Pressure Leaks Down

  1. Ignition OFF, relieve the fuel pressure. Refer to Fuel Pressure Relief .
  2. Install the EN-37287  Fuel Line Shut-Off Adapters between the fuel feed pipe and the fuel rail.
  3. Open the valve on the EN-37287  Fuel Line Shut-Off Adapters.
  4. Ignition ON, command the Fuel Pump Enable On with a scan tool.
  5. Close the valve on the EN-37287  Fuel Line Shut-Off Adapters.
  6. Verify the Chassis Control Module Fuel Pressure parameter does not decrease greater than 34 kPa (5 PSI) in 1 min.
    • If the fuel pressure drops 

      Replace the G12 Fuel Pump.

    • Go to next step: If the fuel pressure does not drop 
  7. Locate and replace the leaking Q17 Fuel Injector.

Fuel Pressure Drops OFF

  1. Verify none of the conditions listed below exist:
    • Restricted fuel feed pipe
    • Restricted or plugged strainer
    • Inspect the harness connectors and the ground circuits of the fuel pump for poor connections.
    • If a condition exist 

      Repair as necessary.

    • Go to next step: If a condition does not exist 
  2. Test or replace the G12 Fuel Pump.
scientia non olet · About LEMON Manuals