LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2020 >> Malibu LS >> Repair and Diagnosis >> External Pages >> Different car >> Section 80 (Steering Wheel And Column) >> Repair Instructions >> Intermediate Steering Shaft Boot Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2019 Chevrolet Malibu. However, it is still accessible from the selected car via links, so may be relevant.
GM4254411Courtesy of GENERAL MOTORS COMPANY
  1. Position a NEW intermediate steering shaft boot clamp (1) onto the intermediate steering shaft boot.
    GM4249198Courtesy of GENERAL MOTORS COMPANY
  2. Intermediate Steering Shaft Boot (1) Install
    GM5043366Courtesy of GENERAL MOTORS COMPANY
  3. Intermediate Steering Shaft (1) Install - Intermediate Steering Shaft Replacement 
    GM4249183Courtesy of GENERAL MOTORS COMPANY
  4. Slide the intermediate steering shaft boot downwards and onto the steering gear.
  5. Use the DT-35910 pliers (1) to install the NEW intermediate steering shaft boot clamp.
  6. Install the left front tire and wheel assembly.TIRE AND WHEEL REMOVAL AND INSTALLATION
    GM5043350Courtesy of GENERAL MOTORS COMPANY
  7. Intermediate Steering Shaft Inner Boot (1) Install - Intermediate Steering Shaft Inner Boot Replacement 
  8. Upper Intermediate Steering Shaft Install - Upper Intermediate Steering Shaft Replacement 
  9. Floor Front Air Outlet Duct - Left Side Install - Floor Front Air Outlet Duct Replacement - Left Side
    GM5034927Courtesy of GENERAL MOTORS COMPANY
  10. Remove the CH-42640 Steering Column Anti-Rotation Pin (1) from the steering column lower access hole.
scientia non olet · About LEMON Manuals