LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2020 >> Express 2500 LS, 6.0L Eng VIN G >> Repair and Diagnosis >> External Pages >> Different car >> Section 56 (Automatic Transmission - 6L90 (MYD) - Diagnostic Information And Procedures) >> Diagnostic Information and Procedures >> No Third, Fifth, and Reverse Gear

No Third, Fifth, and Reverse Gear

WARNING: This page is about a different car, the 2019 GMC Savana 3500, 2019 GMC Savana 2500, 2019 Chevrolet Express 3500, and 2019 Chevrolet Express 2500. However, it is still accessible from the selected car via links, so may be relevant.
Checks Causes
A/Trans Fluid Pan Assembly (29) Verify proper fluid level and condition, inspect transmission assembly for leaks.
Control Valve Upper Body Assembly (304)
  • Inspect for sticking, damaged, or worn 3-5-R regulator valve (336) and valve spring (326).
  • Inspect for damaged or stuck #7 ball check valve.
Control Valve Lower Body Assembly (307) Inspect for worn, damaged, or sticking clutch select solenoid valve 3 (352) and valve spring (353).
1-2-3-4 and 3-5-R Clutch Assembly (51)
  • Inspect for proper installation of 3-5-R clutch backing plate retaining ring (400).
  • Inspect for worn, damaged, or leaking clutch bearing seal assembly (428).
  • Inspect for damaged or worn 3-5-R clutch plates (401 - 404).
  • Inspect for damaged 3-5-R clutch piston (421), apply ring (405), and spring (420).
  • Inspect for cut, worn, or damaged 3-5-R clutch piston dam O-ring seal (418), inner seal (419), and outer seal (422).
  • Inspect for improper selective 3-5-R clutch backing plate retaining ring (400).
Control Solenoid (w/Body and TCM) Valve Assembly (314) Pressure control solenoid 2 commanded/failed HIGH (off) or leaking - Perform solenoid valve assembly function test. Refer to Control Solenoid Valve and Transmission Control Module Assembly Solenoid Performance Test .
A/Trans Fluid Pump (Transfer) Seal Assembly (19) Inspect for damage or leaks.
scientia non olet · About LEMON Manuals