LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2020 >> Express 2500 LS, 6.0L Eng VIN G >> Repair and Diagnosis >> External Pages >> Different car >> Section 5 (Engine Controls And Fuel - 4.3L (LV1) - Repair Instructions) >> Repair Instructions >> Fuel Tank Replacement (Long Wheel Base) >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2019 GMC Savana 3500, 2019 GMC Savana 2500, 2019 Chevrolet Express 3500, and 2019 Chevrolet Express 2500. However, it is still accessible from the selected car via links, so may be relevant.
    WARNING:

    Refer to Diesel/Gasoline Vapors Warning .

    WARNING:

    Refer to Safety Glasses Warning .

  1. Relieve the fuel system pressure. Fuel Pressure Relief 
  2. Drain the fuel tank. Fuel Tank Draining 
  3. Raise and support the vehicle. Lifting and Jacking the Vehicle .
  4. GM4845810Courtesy of GENERAL MOTORS COMPANY

    Evaporative Emission Hose(1) - Disconnect - Plastic Collar Quick Connect Fitting Service 

  5. Fuel Tank Filler Hose Clamp(2) - Remove
  6. Fuel Tank Filler Hose(3) - Remove
  7. GM4846245Courtesy of GENERAL MOTORS COMPANY

    Electrical Connector(1) - Disconnect

  8. Evaporative Emission Front Pipe(2) - Disconnect - Plastic Collar Quick Connect Fitting Service 
  9. Fuel Feed Pipe(3) - Disconnect - Metal Collar Quick Connect Fitting Service 
  10. GM4846246Courtesy of GENERAL MOTORS COMPANY

    Place a suitable adjustable jack under the fuel tank.

  11. Use a suitable strap to strap fuel tank to jack.
  12. Fuel Tank Strap Bolt(1) - Remove[2x]
  13. Fuel Tank Strap(2) - Remove[2x]
  14. Partially lower the fuel tank to disconnect the fuel tank fuel pump module and fuel tank pressure sensor connector.
  15. GM4846247Courtesy of GENERAL MOTORS COMPANY

    Fuel Tank(1) - Remove

  16. If replacing fuel tank transfer parts as necessary.