LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2018 >> Spark LT, Automatic CVT Trans >> Repair and Diagnosis >> External Pages >> Different car >> Section 66 (HVAC System - Automatic) >> Diagnostic Information and Procedures >> DTC P0645, P0646 or P0647: Air Conditioning (A/C) Compressor Clutch Relay Control Circuit >> Component Testing >> Relay Test

Relay Test

WARNING: This page is about a different car, the 2017 Chevrolet Spark. However, it is still accessible from the selected car via links, so may be relevant.
  1. Ignition OFF, disconnect the KR29 A/C Compressor Clutch Relay.
  2. Test for 70 - 110 Ω between terminals 85 and 86.
    • If less than 70 Ω or greater than 110 Ω 

      Replace the KR29 A/C Compressor Clutch Relay.

    • If between 70 - 110 Ω 
  3. Test for infinite resistance between the terminals listed below:
    • 30 and 86
    • 30 and 87
    • 30 and 85
    • 85 and 87
    • If less than infinite resistance 

      Replace the KR29 A/C Compressor Clutch Relay.

    • If infinite resistance 
  4. Install a 20 A fused jumper wire between relay terminal 85 and 12 V. Install a jumper wire between relay terminal 86 and ground.
  5. Test for less than 2 Ω between terminals 30 and 87.
    • If 2 Ω or greater 

      Replace the KR29 A/C Compressor Clutch Relay.

    • If less than 2 Ω 
  6. All OK
scientia non olet · About LEMON Manuals