Fastener Specifications
WARNING: This page is about a different variant/trim than selected.
Single Use Non-Threaded Fasteners/Components
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|---|
| Application |
| Charge Air Bypass Regulator Solenoid Valve Vacuum Tube Seal |
| Emission Reduction Fluid Supply Pump Module O-Ring |
| Exhaust Gas Recirculation Cooler housing Gasket |
| Exhaust Gas Recirculation Cooler Outlet Pipe Gasket |
| Exhaust Gas Recirculation Cooler Outlet Pipe Seal |
| Exhaust Gas Recirculation Cooler Pipe Gasket |
| Exhaust Gas Recirculation Valve Gasket |
| Exhaust Gas Recirculation Valve Seat Gasket |
| Exhaust Manifold Pipe Gasket |
| Exhaust Pressure Differential Sensor Hose Clamp |
| Fuel Filter Seal |
| Fuel Injection Pump Metering Valve O-Ring |
| Fuel Injection Pump Seal Ring |
| Fuel Injection Pump Sprocket Access Hole Plug |
| Fuel Injector Fuel Return Hose Seal Ring |
| Fuel Injector Washer |
| Fuel Return Hose Clamp |
| Fuel Tank Fuel Pump Module O-Ring |
| Throttle Body Gasket |
Single Use Threaded Fastener/Component Tightening Specifications
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Fuel Injection Fuel Feed Pipe | 28 N.m (21 lb ft) |
| Fuel Injector Bracket Bolt | |
|
10 N.m (89 lb in) |
|
60 Degrees |
| Fuel Pressure Sensor | 35 N.m (26 lb ft) |
Reusable Threaded Fastener Tightening Specifications
|
NOTE:
All fasteners listed in this table can be reused after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Accelerator Pedal Position Sensor Bolt | 9 N.m (80 lb in) |
| Air Cleaner Bolt | 9 N.m (80 lb in) |
| Air Cleaner Outlet Duct Clamp | 3.5 N.m (31 lb in) |
| Air Cleaner Upper Housing Bolt | 4 N.m (35 lb in) |
| Camshaft Position Sensor Bolt | 10 N.m (89 lb in) |
| Charge Air Bypass Regulator Solenoid Valve Vacuum Tube Bracket Bolt | 10 N.m (89 lb in) |
| Charge Air Cooler Bolt | 9 N.m (80 lb in) |
| Charge Air Temperature Sensor | 19 N.m (14 lb ft) |
| Crankshaft Position Sensor Bolt | 10 N.m (89 lb in) |
| Diesel Fuel Separator Bolt | 10 N.m (89 lb in) |
| Emission Reduction Fluid Controller Bolt | 2 N.m (18 lb in) |
| Emission Reduction Fluid Injector Nut | 9 N.m (80 lb in) |
| Emission Reduction Fluid Tank Bolt - M8 | 22 N.m (16 lb ft) |
| Emission Reduction Fluid Tank Bolt - M10 | 58 N.m (43 lb ft) |
| Engine Coolant Temperature Sensor | 45 N.m (33 lb ft) |
| Engine Oil Pressure Sensor | 35 N.m (26 lb ft) |
| Engine Wiring Harness Conduit Bolt | 9 N.m (80 lb in) |
| Exhaust Gas Recirculation Cooler Housing Bolt | 25 N.m (18 lb ft) |
| Exhaust Gas Recirculation Cooler Outlet Pipe Bolt | 10 N.m (89 lb in) |
| Exhaust Gas Recirculation Cooler Temperature Sensor | 45 N.m (33 lb ft) |
| Exhaust Gas Recirculation Pipe Bolt | 10 N.m (89 lb in) |
| Exhaust Gas Recirculation Vacuum Regulator Solenoid Valve Bolt | 7 N.m (62 lb in) |
| Exhaust Gas Recirculation Valve Bolt | 10 N.m (89 lb in) |
| Exhaust Manifold Pipe Bolt | 10 N.m (89 lb in) |
| Exhaust Particulate Sensor | 45 N.m (33 lb ft) |
| Exhaust Particulate Sensor Control Module Bracket Nut | 9 N.m (80 lb in) |
| Exhaust Pressure Differential Sensor Bolt | 9 N.m (80 lb in) |
| Exhaust Pressure Differential Sensor Bracket Bolt | 9 N.m (80 lb in) |
| Exhaust Temperature Sensor | 45 N.m (33 lb ft) |
| Front Intake Air Duct Nut | 9 N.m (80 lb in) |
| Fuel Filter Drain Plug | 1.6 N.m (14 lb in) |
| Fuel Cooler Bolt | 9 N.m (80 lb in) |
| Fuel Injection Fuel Feed Pipe Bracket Bolt | 9 N.m (80 lb in) |
| Fuel Injection Fuel Rail Bolt | 25 N.m (18 lb ft) |
| Fuel Injection Pump Driven Sprocket Nut | 64 N.m (47 lb ft) |
| Fuel Injection Pump Metering Valve Fastener | 9 N.m (80 lb in) |
| Fuel Injection Pump Bolt | 25 N.m (18 lb ft) |
| Fuel Injection Pump Drive Pulley Nut | 64 N.m (47 lb ft) |
| Fuel Pump Power Control Module Bolt | 9 N.m (80 lb in) |
| Fuel Pump Power Control Module Bracket Bolt | 9 N.m (80 lb in) |
| Fuel Pump Power Control Module Nut | 9 N.m (80 lb in) |
| Fuel Tank Filler Hose Clamp | 4 N.m (35 lb in) |
| Fuel Tank Filler Pipe Ground Bolt | 9 N.m (80 lb in) |
| Fuel Tank Strap Bolt | 22 N.m (16 lb ft) |
| Fuel/Water Separator Reservoir | 25 N.m (18 lb ft) |
| Glow Plug | 16.5 N.m (12 lb ft) |
| Heater Inlet Pipe Bracket Bolt | 9 N.m (80 lb in) |
| Intake Air Pressure and Temperature Sensor Bolt | 1.6 N.m (14 lb in) |
| Intake Manifold Brace Bolt | 10 N.m (89 lb in) |
| Mass Airflow Sensor Bolt | 4 N.m (35 lb in) |
| Nitrogen Oxides Sensor | 50 N.m (37 lb ft) |
| Nitrogen Oxides Sensor Control Module Nut | 9 N.m (80 lb in) |
| Nitrogen Oxides Sensor Nut | 9 N.m (80 lb in) |
| Oil Pump Flow Control Solenoid Valve Bolt | 10 N.m (89 lb in) |
| Piston Oil Nozzle Oil Control Solenoid Valve Bolt | 10 N.m (89 lb in) |
| Power Brake Booster Inlet Hose Connector Fitting Bolt | 10 N.m (89 lb in) |
| Power Brake Booster Inlet Hose Connector Fitting Bracket Bolt | 10 N.m (89 lb in) |
| Radiator Surge Tank Outlet Hose Bracket Bolt | 10 N.m (89 lb in) |
| Throttle Body Bolt | 10 N.m (89 lb in) |
| Transmission Bolt | 58 N.m (43 lb ft) |
| Turbocharger Actuator Pipe Bracket Bolt | 10 N.m (89 lb in) |
| Turbocharger Wastegate Actuator Pipe Bolt | 10 N.m (89 lb in) |
| Turbocharger Wastegate Actuator Pipe Nut | 10 N.m (89 lb in) |
| Turbocharger Wastegate Actuator Vacuum Control Solenoid Valve Bolt | 10 N.m (89 lb in) |
| Turbocharger Wastegate Actuator Vacuum Control Solenoid Valve Bracket Bolt | 10 N.m (89 lb in) |