LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2017 >> Suburban 3500 HD LS >> Repair and Diagnosis >> Accessories & Equipment >> Interior/Exterior Trim >> Bolted Exterior Body Panels And Closures >> Repair Instructions >> Front Side Door Replacement

Front Side Door Replacement

Fig 1: Front Side Door
GM3611697Courtesy of GENERAL MOTORS COMPANY
Callout Component Name
WARNING:

Refer to SIR Warning .

Preliminary Procedures

  1. Open the door to the full open position.
  2. Disable the supplementary inflatable restraint (SIR) system. Refer to SIR Disabling and Enabling .
  3. Mark the location of the hinge before removing the bolts with a grease pencil.
  4. Remove the front side door pull handle bracket. Refer to Front Side Door Pull Handle Bracket Replacement .
  5. Remove the water deflector.
1 Front Side Door Check Link Bolt
CAUTION:

Refer to Fastener Caution .

Procedure

  1. Disconnect the electrical connector.
  2. Slide the front side door check link cover rearward to gain access to the bolt, if required.
  3. Support the door before removing the hinge bolts.
  4. With an assistant, remove the door.

Tighten 
22 N.m (16 lb ft)
2 Front Side Door Lower Hinge Bolt (Qty: 2)
Tighten 
25 N.m (18 lb ft)
3 Front Side Door Upper Hinge Bolt (Qty: 2)
Tighten 
25 N.m (18 lb ft)
4 Front Side Door

Procedure

  1. Transfer all necessary components.
  2. Adjust the front side door, if needed. Refer to Front Side Door Adjustment .
NOTE:

Inspect the door for proper operation before installing the door trim.
scientia non olet · About LEMON Manuals