LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2015 >> Cruze LT, Automatic Trans >> Repair and Diagnosis >> External Pages >> Different car >> Section 86 (Engine Controls And Fuel - 1.4L (LUJ LUV) - DTC P0300 To DTC P2635 And Diagnostic Information And Procedures) >> Diagnostic Information and Procedures >> Poor Fuel Fill Quality

Poor Fuel Fill Quality

WARNING: This page is about a different car, the 2015 Chevrolet Trax and 2015 Buick Encore. However, it is still accessible from the selected car via links, so may be relevant.
Condition Causes
DEFINITION: During the fueling process a continual, occasional or no fuel nozzle shut-off condition has occurred.
Difficult to fill
  • Fuel fill limiter vent valve stuck closed
  • Evaporative emission (EVAP) canister restricted
  • High fuel temperature
  • Fuel filler hose is kinked
  • Faulty dispensing nozzle
Over fill
  • Fill limiter vent valve stuck open or leaking
  • Fuel inlet check valve stuck open
Premature shut-off of the fuel dispensing nozzle occurs immediately after engaging dispensing nozzle, tank empty
  • Restricted vapor lines or fuel fill pipe
  • High fuel temperature
  • Inlet check valve at tank stuck closed, fill pipe full of fuel
  • Fuel tank full, gauge not accurate
Premature shut-off of the fuel dispensing nozzle, more than 1/8 of tank capacity dispensed
  • Kinked, pinched or plugged lines in fuel tank vent system
  • EVAP canister restricted
  • Fuel limiting vent valve stuck closed or obstruction at top of fuel tank
Fuel spitback
  • Restricted EVAP canister
  • High fuel temperature
scientia non olet · About LEMON Manuals