LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2014 >> Trax LTZ, FWD >> Repair and Diagnosis >> Engine Mechanical >> Blowers, Superchargers & Turbochargers >> Engine Controls And Fuel - 1.4L (LUJ LUV) - Repair Instructions >> Repair Instructions >> Charge Air Cooler Outlet Air Hose Replacement >> Installation Procedure

Installation Procedure

    Fig 1: Charge Air Cooler, Outlet Air Hose & Retainer Spring
    GM2552472Courtesy of GENERAL MOTORS COMPANY
  1. Install the charge air cooler outlet air hose (2) to charge air cooler (3).
  2. Clip the in retainer spring (1).
    3. Fig 2: Charge Air Cooler Outlet Air Pipe To Frame Bracket
    GM2771844Courtesy of GENERAL MOTORS COMPANY
  3. Install the fasteners (1) to the charge air cooler outlet air pipe to frame bracket (2).
    4. Fig 3: Charge Air Cooler Outlet Air Hose, Throttle Body & Clamp
    GM2675424Courtesy of GENERAL MOTORS COMPANY
  4. Install the charge air cooler inlet air pipe to the turbocharger.
    5. CAUTION:

    Refer to Fastener Caution .

  5. Tighten the clamp (1).
  6. Connect the intake air pressure and temperature sensor electrical connector.
  7. Install the front bumper fascia. Refer to Front Bumper Fascia Replacement (Trax) , Front Bumper Fascia Replacement (Encore) .
scientia non olet · About LEMON Manuals