LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2013 >> Cruze LT, Automatic Trans >> Repair and Diagnosis >> Heating, Ventilation & A/C (HVAC) >> HVAC Control Systems >> Heating, Ventilation, And Air Conditioning >> Repair Instructions >> Air Conditioning Compressor Replacement (1.8L LUW and LWE)

Air Conditioning Compressor Replacement (1.8L LUW and LWE)

Fig 1: Air Conditioning Compressor And Bolts
GM2189390Courtesy of GENERAL MOTORS COMPANY
Air Conditioning Compressor Replacement (1.8L LUW and LWE)

Callout Component Name

Preliminary Procedures

  1. Recover the refrigerant. Refer to Refrigerant Recovery and Recharging .
  2. Remove the drive belt. Refer to Drive Belt Replacement .
  3. Disconnect the air conditioning compressor electrical connector.
  4. Loosen the air conditioning compressor and condenser hose from the air conditioning compressor. Refer to Air Conditioning Compressor and Condenser Hose Replacement (1.8L LUW and LWE) , Air Conditioning Compressor and Condenser Hose Replacement (1.4L LUV) .
1 Air Conditioning Compressor Bolt (Qty: 3)
CAUTION:

Refer to Fastener Caution .


Tighten 
22 (17 lb ft)
2 Air Conditioning Compressor

Procedure

  • Use a low viscosity, poly-alkylene glycol (PAG) oil. Use of the incorrect oil can result in compressor failure.
  • When replacing the A/C compressor, balance the compressor oil. Refer to Air Conditioning Compressor Oil Balancing 
  • Use GE-39400  detector leak test A/C compressor fittings.

Special Tools 
GE-39400  Electronic Halogen Leak Detector
For equivalent regional tools, refer to Special Tools .
scientia non olet · About LEMON Manuals