LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2012 >> Tahoe PPV >> Repair and Diagnosis >> External Pages >> Different car >> Section 1286 (Floor Coverings And HEADLININGS) >> Repair Instructions >> Headlining Trim Panel Replacement (Extended Cab)

Headlining Trim Panel Replacement (Extended Cab)

WARNING: This page is about a different car, the 2009 GMC Sierra, 2009 GMC Cab & Chassis Sierra, 2009 Chevrolet Silverado, and 2009 Chevrolet Cab & Chassis Silverado. However, it is still accessible from the selected car via links, so may be relevant.
Fig 1: View Of Headlining Trim Panel
GM1714381Courtesy of GENERAL MOTORS CORP.
Callout Component Name
WARNING: Do not attempt to repair or alter the head impact energy-absorbing material glued to the headliner or to the garnish trims. If the material is damaged, replace the headliner and/or the garnish trim. Failure to do so could result in personal injury.

Preliminary Procedures

  1. Disable the SIR system. Refer to SIR Disabling and Enabling .
  2. Remove the windshield garnish moldings. Refer to Windshield Pillar Garnish Molding Replacement .
  3. Remove the sunshade assemblies. Refer to Sunshade Replacement .
  4. Remove the roof console assembly. Refer to Roof Console Replacement .
  5. Remove the roof rail assist handles. Refer to Roof Rail Rear Assist Handle Replacement .
  6. Remove the body lock pillar trim panels. Refer to Body Lock Pillar Trim Replacement (Crew Cab) , Body Lock Pillar Trim Replacement (Extended Cab) or Body Lock Pillar Trim Replacement (Regular Cab) .
  7. Remove the sunroof finishing lace, if equipped. Refer to Sunroof Opening Trim Finish Lace Replacement (Extended Cab) .
  8. Remove the dome lamp, if equipped. Refer to Dome Lamp Replacement .
  9. Remove the second seat overhead console, if equipped. Refer to Roof Rear Console Replacement (with DVD) .
  10. Remove either the driver or passenger front seat belt assembly. Refer to Seat Belt Retractor Pretensioner Replacement - Front (Regular Cab) , Seat Belt Retractor Pretensioner Replacement - Front (Extended Cab) or Seat Belt Retractor Pretensioner Replacement - Front (Crew Cab) .
1 Headliner Trim Panel Retainer (Qty: 2)
2 Sunshade Anchor (Qty: 2)
Refer to Sunshade Anchor Replacement .
3 Headliner Trim Panel Assembly

Procedure

  1. Remove the front seat headrest to aid in removal of headliner from vehicle.
  2. Prior to removal, note the routing of the wire harness to aid in reassembly and to ensure proper installation.
  3. Disconnect the electrical connector.
scientia non olet · About LEMON Manuals