LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2009 >> Corvette Base, 2D Convertible, Automatic >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 1 (Manual Transmission - TREMEC 6-Speed) >> Repair Instructions - On Vehicle >> Transmission Fluid Cooler Lower Pipe Replacement - Intermediate to Differential Cooler >> Removal Procedure

Removal Procedure

WARNING: This page is about a different variant/trim than selected.
  1. Raise and support the vehicle. Refer to Lifting and Jacking the Vehicle .
  2. Install a drain pan under the vehicle.
    3. Fig 1: View Of Intermediate Transmission Fluid Cooler Lower Pipe At Rear Transmission Lower Pipe
    GM1507119Courtesy of GENERAL MOTORS CORP.
    IMPORTANT: Cap or plug the open transmission fluid cooler pipes immediately to prevent system contamination.
  3. Disconnect the intermediate transmission fluid cooler lower pipe from the rear transmission lower pipe. Refer to Transmission Fluid Cooler Hose/Pipe Quick-Connect Fitting Disconnection and Connection .
    4. Fig 2: View Of Transmission Fluid Cooler Pipes At Differential Oil Cooler
    GM1503938Courtesy of GENERAL MOTORS CORP.
  4. Remove the transmission cooler pipe clip.
  5. Remove the rear transmission lower pipe from the differential oil cooler. Refer to Transmission Fluid Cooler Hose/Pipe Quick-Connect Fitting Disconnection and Connection .
  6. Remove the rear transmission fluid cooler lower pipe from the vehicle.
scientia non olet · About LEMON Manuals