LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2008 >> Optra LT, Automatic >> Repair and Diagnosis >> Transmission >> Hydraulic Diagrams >> Automatic Transaxle - ZF 4HP 16 - Service, Overhaul, Removal & Installation, Troubleshooting & Diagnosis >> Brake F, Slotted Nut Removal >> Removal

Brake F, Slotted Nut Removal: Removal

    CAUTION: Refer to Safety Glasses Caution .
  1. Remove the side shaft. Refer to Side Shaft Removal .
    2. Fig 1: View Of Disc Set
    GM1256023Courtesy of GENERAL MOTORS CORP.
  2. Remove the disc set.
    3. Fig 2: Identifying F Brake Inner Disc Carrier
    GM1256024Courtesy of GENERAL MOTORS CORP.
  3. Remove the brake F inner disc carrier.
    4. Fig 3: View Of DT 46474 And F Split Stop Ring
    GM1256025Courtesy of GENERAL MOTORS CORP.
  4. Install DT 46474  (1) and remove the brake F split stop ring. See Special Tools .
  5. Remove DT 46474  (1). See Special Tools .
    6. Fig 4: View Of Cup Spring
    GM1256026Courtesy of GENERAL MOTORS CORP.
  6. Remove the cup spring.
    7. Fig 5: Applying Compressed Air To Bore To Release Piston F
    GM1256028Courtesy of GENERAL MOTORS CORP.
  7. Release the piston F by applying compressed air to the bore.
    8. Fig 6: View Of Bearing Plate
    GM1256030Courtesy of GENERAL MOTORS CORP.
    IMPORTANT: Remove the plate by pressing the plate upward from beneath.
  8. Remove piston F and remove the bearing plate with the spur gear.
scientia non olet · About LEMON Manuals