LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2008 >> Express 1500 AWD V8-5.3L >> Repair and Diagnosis >> Heating and Air Conditioning >> Air Duct >> Service and Repair >> Windshield Defroster Duct Replacement

Windshield Defroster Duct Replacement



Windshield Defroster Duct Replacement

Removal Procedure

1. Remove the engine cover.
2. Remove the I/P carrier.




3. Remove the windshield defrost duct retaining screws at the heater case.
4. Remove the windshield defrost duct retaining nuts at the cowl.
5. Remove the windshield defrost duct (5) from the vehicle.

Installation Procedure




1. Install the windshield defrost duct (5) to the vehicle.

Notice: Refer to Fastener Notice.

2. Install the windshield defrost duct retaining nuts to the cowl.

Tighten the nuts to 4 N.m (35 lb in).

3. Install the windshield defrost duct retaining screws to the heater case.

Tighten the screws to 4 N.m (35 lb in).

4. Install the I/P carrier.
5. Install the engine cover.
scientia non olet · About LEMON Manuals