LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2007 >> Chevy Express G2500, Van Cargo, 6.6 6 >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 5 (Engine Control System & Fuel System - 4.8L, 5.3L, And 6.0L - Introduction (2 Of 2)) >> Repair Instructions >> Fuel Hose/Pipes Assembly Replacement (Cutaway Van Side Tank) >> Removal Procedure

Removal Procedure

WARNING: This page is about a different variant/trim than selected.
    Fig 1: View Of Fuel Fill Hose
    GM601679Courtesy of GENERAL MOTORS CORP.
    CAUTION: Refer to BATTERY DISCONNECT CAUTION .
  1. Disconnect the negative battery cable.
  2. Clean all the fuel pipe and hose connections and the surrounding areas before disconnecting in order to avoid possible contamination of the fuel system.
  3. Remove the fuel filler cap.
  4. Drain the fuel below the level of the fuel tank fill hose. Refer to Fuel Tank Draining .
  5. Raise the vehicle. Refer to Lifting and Jacking the Vehicle .
  6. Loosen the fuel fill hose clamps (2, 3).
  7. Remove the fuel fill hose (6).
  8. Cap the open end of the fuel tank.
scientia non olet · About LEMON Manuals