LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2007 >> Chevy Express G2500, Van Cargo, 6.6 6 >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 5 (Engine Control System & Fuel System - 4.8L, 5.3L, And 6.0L - Introduction (2 Of 2)) >> Repair Instructions >> Fuel Hose/Pipes Assembly Replacement (Cutaway Van Side Tank) >> Installation Procedure

Installation Procedure

WARNING: This page is about a different variant/trim than selected.
    Fig 1: View Of Fuel Fill Hose
    GM601679Courtesy of GENERAL MOTORS CORP.
  1. Uncap the fuel tank.
    2. NOTE: Refer to FASTENER NOTICE .
  2. Install the fuel fill hose (6).

    Tighten:  Tighten the fuel fill hose clamps (2, 3) to 2.75 N.m (24 lb in).

  3. Lower the vehicle.
  4. Refill the fuel tank.
  5. Install the fuel filler cap.
  6. Connect the negative battery cable.
scientia non olet · About LEMON Manuals