LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2007 >> Chevy Express G2500, Van Cargo, 6.6 6 >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 10 (Engine Control System & Fuel System - 6.6L (LLY) - DTC P0016 To DTC P0341) >> DTC P0168 >> Circuit/System Testing

Circuit/System Testing

WARNING: This page is about a different variant/trim than selected.
IMPORTANT: Fuel temperature overheating may be cause by a fuel heater element that is stuck on. Refer to Fuel Heater Always On .
  1. With ignition ON and the engine OFF, observe the Fuel Temperature and ECT Temperature parameters with a scan tool.
    • If the temperatures do not closely match each other when the engine has cold soaked overnight, test for a skewed fuel temperature sensor. Refer to Component Testing in the diagnostic.
  2. Inspect for debris or damage to the cooling fins of the fuel cooler.
    • If a damaged fuel cooler was found, repair or replace the cooler.
scientia non olet · About LEMON Manuals