LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2006 >> Silverado 1500 HD, RWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 880 (Engine Controls And Fuel - 4.8L, 5.3L, 6.0L And 6.2L - Introduction (2 Of 2)) >> Repair Instructions >> Evaporative Emission Canister Vent Solenoid Valve Replacement (35 Reg/Ext/Crew Cab w/8Ft Bed) >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2007 GMC Sierra, 2007 GMC Cab & Chassis Sierra, 2007 Chevrolet Silverado, and 2007 Chevrolet Cab & Chassis Silverado. However, it is still accessible from the selected car via links, so may be relevant.
IMPORTANT: Clean the evaporative emission (EVAP) connections and surrounding areas prior to disconnecting the fittings in order to avoid possible system contamination.
    Fig 1: EVAP Canister Vent Solenoid Clip And EVAP Canister Vent Solenoid Pipe Clip
    GM1855687Courtesy of GENERAL MOTORS CORP.
  1. Raise and suitably support the vehicle. Refer to Lifting and Jacking the Vehicle .
  2. Remove EVAP canister vent solenoid clip (1) from the chassis EVAP line.
  3. Remove the EVAP canister vent solenoid pipe from the clip (2) on the chassis EVAP line.
  4. Remove the EVAP canister vent solenoid pipe from the clips (3) on the brake pipes.
  5. Disconnect the chassis wiring harness electrical connector from the EVAP canister vent solenoid.
    6. Fig 2: Fittings At Fuel Tank
    GM1854924Courtesy of GENERAL MOTORS CORP.
  6. Disconnect the EVAP vent solenoid pipe quick connect fitting (3) from the EVAP canister. Refer to Plastic Collar Quick Connect Fitting Service .
  7. Remove the EVAP canister vent solenoid pipe clip (1) from the frame crossmember.
    8. Fig 3: EVAP Canister Vent Solenoid Retainer
    GM1855688Courtesy of GENERAL MOTORS CORP.
  8. Disengage the retainer (1) securing the EVAP canister vent solenoid.
  9. Slide the EVAP canister vent solenoid off the bracket towards the passenger side of the vehicle.
    10. Fig 4: EVAP Canister Vent Solenoid
    GM1855691Courtesy of GENERAL MOTORS CORP.
  10. Remove the EVAP canister vent solenoid from the vehicle.
scientia non olet · About LEMON Manuals