LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2006 >> Silverado 1500 HD, 4WD >> Repair and Diagnosis >> External Pages >> Different car >> Section 148 (Engine Mechanical - 4.8L, 5.3L & 6.0L) >> Repair Instructions >> Off-Vehicle Repair Instructions >> Oil Pump, Pump Screen and Deflector Removal

Oil Pump, Pump Screen and Deflector Removal

WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2003 GMC Savana Special, 2003 GMC Savana Camper Special, 2003 GMC Savana, 2003 Chevrolet RV Cutaway, and 2003 Chevrolet Cutaway. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the oil pump screen bolt (4) and nuts (2).
  2. Remove the oil pump screen (1) with O-ring seal (3).
  3. Remove the O-ring seal from the pump screen.
  4. Discard the O-ring seal.
    Fig 1: Removing Oil Pump Screen Bolt, Nuts, Screen & O-Ring Seal
    G02078750Courtesy of GENERAL MOTORS CORP.
  5. Remove the remaining crankshaft oil deflector nuts.
  6. Remove the crankshaft oil deflector.
    Fig 2: Removing Nuts & Crankshaft Oil Deflector
    G02078751Courtesy of GENERAL MOTORS CORP.
  7. Remove the oil pump bolts.

    Important:  Do not allow dirt or debris to enter the oil pump assembly, cap ends as necessary.

  8. Remove the oil pump.
    Fig 3: Removing Oil Pump Bolts & Oil Pump
    G02078752Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals