Sunroof Window Height and Opening Fit Adjustment

WARNING: This page is about a different car, the 2008 Pontiac G5 and 2008 Chevrolet Cobalt. However, it is still accessible from the selected car via links, so may be relevant.

Open the sunshade.
Close the sunroof window.

Fig 1: View Of Sunroof

Courtesy of GENERAL MOTORS CORP.

Loosen the adjusting screws.
Adjust the corners of the glass panel (3) using the following guidelines:
- Adjust the front of the sunroof window (2) flush to 1 mm (0.04 in) below the top surface of the roof panel.
- Adjust the rear of the sunroof window (1) flush to 1 mm (0.04 in) above the top surface of the roof panel.

NOTE: Refer to Fastener Notice .

Install the sunroof window adjustment screws.
Tighten: Tighten the sunroof window adjusting screws to 6 N.m (53 lb in).