LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2006 >> Cobalt LTZ >> Repair and Diagnosis >> External Pages >> Different car >> Section 766 (Engine Control System & Fuel System - 2.4L - Introduction (2 Of 2)) >> Repair Instructions >> Air Cleaner Outlet Duct Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2008 Pontiac G5 and 2008 Chevrolet Cobalt. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: View Of Air Cleaner Outlet Duct
    GM1657019Courtesy of GENERAL MOTORS CORP.
  1. Remove the intake manifold cover. Refer to Intake Manifold Cover Replacement .
  2. Loosen the clamps at the air cleaner housing and throttle body.
  3. Reposition the positive crankcase ventilation (PCV) hose clamp at the camshaft cover.
  4. Remove the PCV hose from the camshaft cover.
  5. Remove the push pin retainer.
  6. Remove the air cleaner outlet duct.
    7. Fig 2: View Of PCV Hose From Outlet Duct
    GM1656106Courtesy of GENERAL MOTORS CORP.
  7. If necessary, reposition the PCV hose clamp at the outlet duct.
  8. If necessary, remove the PCV hose from the outlet duct.
scientia non olet · About LEMON Manuals