LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2006 >> Cobalt LTZ >> Repair and Diagnosis >> External Pages >> Different car >> Section 683 (Sunroof System) >> Repair Instructions >> Sunroof Motor/Actuator Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2007 Pontiac G5 Pursuit, 2007 Pontiac G5, and 2007 Chevrolet Cobalt. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: Sunroof Motor/Actuator
    GM1547332Courtesy of GENERAL MOTORS CORP.
  1. Synchronize the sunroof motor/actuator (1). Refer to Sunroof Motor Synchronization .
  2. Install the sunroof motor/actuator (1) to the sunroof module.
    3. NOTE: Refer to Fastener Notice .
  3. Install the sunroof motor/actuator bolts (2).

    Tighten:  Tighten the bolts to 5 N.m (44 lb in).

    4. Fig 2: View Of Sunroof Motor/Actuator Electrical Connector
    GM861204Courtesy of GENERAL MOTORS CORP.
  4. Connect the electrical connector to the sunroof motor/actuator.
  5. Secure the electrical harness to the sunroof module.
  6. Verify the sunroof operation.
  7. Install the headliner. Refer to Headlining Trim Panel Replacement .
  8. Refer to Control Module References .
scientia non olet · About LEMON Manuals