LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2006 >> Cobalt LTZ >> Repair and Diagnosis >> External Pages >> Different car >> Section 683 (Sunroof System) >> Repair Instructions >> Sunroof Housing Front Drain Hose Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2007 Pontiac G5 Pursuit, 2007 Pontiac G5, and 2007 Chevrolet Cobalt. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the headliner. Refer to Headlining Trim Panel Replacement .
    2. Fig 1: Sunroof Drain Hose
    GM1547473Courtesy of GENERAL MOTORS CORP.
  2. Remove the front drain hose from the sunroof module.
  3. Disengage the sunroof drain hose from the attachment points on the windshield pillar.
  4. Remove the carpet retainer. Refer to Front Carpet Retainer Replacement (Coupe) or Front Carpet Retainer Replacement (Sedan) .
  5. Pull back the front lower insulator.
  6. Remove the hinge pillar inner insulators to gain access to the front drain hose routing area inside the hinge pillar below the I/P.
  7. Pull the front drain hose out of the front lower hinge pillar.
  8. Tie a 3-foot length of string onto the lower end of the front drain hose.
  9. Remove the hose through the top of the I/P. Do NOT pull the string all of the way out.
  10. Disconnect the string from the hose.
scientia non olet · About LEMON Manuals