Rear Side Door Hinge Replacement

WARNING: This page is about a different car, the 2007 Pontiac G5 Pursuit, 2007 Pontiac G5, and 2007 Chevrolet Cobalt. However, it is still accessible from the selected car via links, so may be relevant.

Fig 1: Hinge Replacement - Rear Door

Courtesy of GENERAL MOTORS CORP.

Callout	Component Name
Rear Side Door Upper Hinge Assembly Replacement IMPORTANT: Replace only one hinge at a time.
1	Rear Side Door Hinge Upper Bolt (Qty: 2) NOTE: Refer to Fastener Notice . Tighten: 35 N.m (26 lb ft)
2	Rear Side Door Hinge Upper Bolt (Qty: 2) Tighten: 25 N.m (18 lb ft)
3	Rear Side Door Upper Hinge Assembly NOTE: Striker alignment is a crucial part of door latch operation. Do not use the door striker to adjust the door to the vehicle. Failure to properly adjust the striker can result in damage to the door latch and the striker. Tip: Check the door for proper alignment, adjust as necessary.
Rear Side Door Lower Hinge Assembly Replacement IMPORTANT: Replace only one hinge at a time.
4	Rear Side Door Hinge Lower Bolt (Qty: 2) Tighten: 35 N.m (26 lb ft)
5	Rear Side Door Hinge Lower Bolt (Qty: 2) Tighten: 25 N.m (18 lb ft)
6	Rear Side Door Lower Hinge Assembly NOTE: Striker alignment is a crucial part of door latch operation. Do not use the door striker to adjust the door to the vehicle. Failure to properly adjust the striker can result in damage to the door latch and the striker. Tip: Check the door for proper alignment, adjust as necessary.