Fastener Tightening Specifications
WARNING: This page is about a different car, the 2007 Pontiac G5 Pursuit, 2007 Pontiac G5, and 2007 Chevrolet Cobalt. However, it is still accessible from the selected car via links, so may be relevant.
Fastener Tightening Specifications
| Application | Specification | |
|---|---|---|
| Metric | English | |
| A/C Refrigerant Pressure Sensor | 5 N.m | 44 lb in |
| Blower Motor Mounting Screws | 1.8 N.m | 16 lb in |
| Blower Motor Nuts | 2.4 N.m | 21 lb in |
| Blower Resister Mounting Screws | 1.8 N.m | 16 lb in |
| Center Air Distribution Duct Retaining Screws | 2.5 N.m | 22 lb in |
| Charge Air Cooler Pump Mounting Clamp Bolt | 10 N.m | 89 lb in |
| Compressor Clutch Drive Plate Bolt | 12 N.m | 106 lb in |
| Compressor Drain Plug | 16 N.m | 12 lb ft |
| Compressor Hose to Compressor Bolt | 20 N.m | 15 lb ft |
| Compressor Hose to Condenser Bolt | 20 N.m | 15 lb ft |
| Compressor Hose to Evaporator Hose Nut | 20 N.m | 15 lb ft |
| Compressor Mounting Bolts | 25 N.m | 18 lb ft |
| Compressor Pressure Relief Valve | 7 N.m | 62 lb in |
| Condenser Mounting Bolts | 10 N.m | 88 lb in |
| Defroster Duct Retaining Screws | 2.5 N.m | 22 lb in |
| Evaporator Inlet Line Clamp Nut | 10 N.m | 88 lb in |
| Evaporator Inlet Line to Condenser Bolt | 20 N.m | 15 lb ft |
| Evaporator Outlet Line to TXV Nut | 20 N.m | 15 lb ft |
| Heater Core Cover Screws | 1.8 N.m | 16 lb in |
| HVAC Module Actuator Screws | 1.8 N.m | 16 lb in |
| HVAC Module Case Screws | 1.8 N.m | 16 lb in |
| HVAC Module to Cross Vehicle Beam Mounting Bolts | 10 N.m | 88 lb in |
| HVAC Module to Dash Panel Nuts | 10 N.m | 88 lb in |
| Instrument Panel (I/P) Carrier Bolts | 25 N.m | 18 lb ft |
| Outer Air Outlet Duct Retaining Screws | 2.5 N.m | 22 lb in |
| Service Port Valve Core | 2.5 N.m | 22 lb in |
| Side Window Duct Retaining Screws | 2.5 N.m | 22 lb in |
| TXV to Evaporator Core Mounting Bolts | 7 N.m | 62 lb in |