LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2005 >> Chevy Express H1500, Van Passenger >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 5 (Automatic Transmission - 4L80-E/4L85-E - Introduction & Repair Instructions) >> Repair Instructions >> Transmission Fluid Auxiliary Cooler Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different variant/trim than selected.
  1. Remove the grille assembly. Refer to Grille Replacement (Uplevel) or Grille Replacement (Base) .
    2. Fig 1: Auxiliary Cooler & Mounting Bracket
    GM765118Courtesy of GENERAL MOTORS CORP.
  2. Disconnect the 2 lines from the auxiliary cooler.
  3. Remove the lines from the push clips on the auxiliary cooler mounting bracket.
  4. Raise the vehicle. Refer to Lifting and Jacking the Vehicle in General Information.
    5. Fig 2: Auxiliary Cooler & Mounting Bracket
    GM765118Courtesy of GENERAL MOTORS CORP.
  5. Remove the lower bolts from the auxiliary cooler mounting bracket.
  6. Lower the vehicle.
  7. Remove the upper bolts.
  8. Remove the auxiliary oil cooler from the vehicle.
scientia non olet · About LEMON Manuals