LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2005 >> Chevy Express H1500, Van Passenger >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 5 (Automatic Transmission - 4L80-E/4L85-E - Introduction & Repair Instructions) >> Repair Instructions >> Forward Servo Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different variant/trim than selected.
  1. Raise the vehicle. Refer to Lifting and Jacking the Vehicle .
  2. Remove the oil pan and filter. Refer to Automatic Transmission Fluid/Filter Replacement .
  3. Remove the six forward servo cover bolts, cover, and gasket.
    4. Fig 1: Forward Servo Assembly
    GM512978Courtesy of GENERAL MOTORS CORP.
  4. Remove the following parts:
    1. Forward servo piston pin (5)
    2. O-ring seal (4)
    3. Servo piston (3)
    4. Retainer (2)
    5. Piston spring (1)
scientia non olet · About LEMON Manuals