LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2005 >> Chevy Express H1500, Van Passenger >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 4 (Automatic Transmission - 4L80-E/4L85-E - Service, Diagnosis & Trouble Shooting) >> Troubleshooting >> Road Test Procedure >> Manual Downshifts

Manual Downshifts

WARNING: This page is about a different variant/trim than selected.

The shift solenoid valves do not control manual downshifts. All manual downshifts are hydraulic. The solenoid states will change during, or shortly after, a manual downshift is selected.

Manual 4-3 Downshift

  1. Place the gear selector in the OVERDRIVE position.
  2. Accelerate the vehicle to 64-88 km/h (40-55 mph) in FOURTH gear.
  3. Release the throttle while moving the gear selector to THIRD.
  4. Verify the following:
    • The transmission downshifts immediately to THIRD gear
    • The engine slows the vehicle

Manual 4-2 Downshift

  1. Place the gear selector in the OVERDRIVE position.
  2. Accelerate the vehicle to 64-72 km/h (40-45 mph).
  3. Release the throttle while moving the gear selector to SECOND.
  4. Verify the following:
    • The TCC releases
    • The transmission downshifts immediately to SECOND gear
    • The engine slows the vehicle

Manual 4-1 Downshift

  1. Place the gear selector in the OVERDRIVE position.
  2. Accelerate the vehicle to 64 km/h (40 mph).
  3. Release the throttle while moving the gear selector to FIRST.
  4. Verify the following:
    • The TCC releases
    • The transmission immediately downshifts to FIRST Gear.
    • The engine slows the vehicle.
scientia non olet · About LEMON Manuals