LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2005 >> Chevy Express H1500, Van Passenger >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 1 (Engine Control System - 4.3L - Introduction) >> Repair Instructions >> Fuel Hose/Pipes Assembly Replacement (Passenger/Cargo Van Fuel Tank Pipes) >> Removal Procedure

Removal Procedure

WARNING: This page is about a different variant/trim than selected.
    Fig 1: Identifying Fuel Tank Components
    GM601669Courtesy of GENERAL MOTORS CORP.
    CAUTION: Refer to Battery Disconnect Caution in Cautions and Notices.
  1. Disconnect the negative battery cable.
  2. Relieve the fuel system pressure. Refer to Fuel Pressure Relief Procedure .
  3. Drain the fuel tank. Refer to Fuel Tank Draining Procedure .
  4. Remove the fuel tank. Refer to Fuel Tank Replacement (Cutaway Van Side Tank)  or Fuel Tank Replacement (Passenger/Cargo Van)  or Fuel Tank Replacement (Cutaway Van Rear Tank) .
  5. Remove the fuel feed and return pipes (6) from the fuel sender (1), the fuel filter, and the retaining clips.
scientia non olet · About LEMON Manuals