Symptoms - Engine Electrical

WARNING: This page is about a different car, the 2004 Suzuki Swift + and 2004 Chevrolet Aveo. However, it is still accessible from the selected car via links, so may be relevant.

IMPORTANT: Review the system operation in order to familiarize yourself with the system functions. Refer to the following:

Visual/Physical Inspection

Inspect for aftermarket devices which could affect the operation of the starting, charging or ignition systems. Refer to Checking Aftermarket Accessories in Wiring Systems.
Inspect the easily accessible or visible system components for obvious damage or conditions which could cause the symptom.
Inspect the battery for correct installation and physical damage.
Test the condition of the battery. Terminal voltage should be 11.5-13.5 volts.
Inspect the wiring for damage. Inspect the connections to the starter motor, the starter solenoid, the ignition switch, the battery and all related ground points.
If the battery, wiring and switches are in satisfactory condition and the engine is known to be functioning properly, remove and test the starter motor.
When the charging system is operating normally, the charge indicator lamp will come ON when the ignition switch is turned ON and will go out when the engine starts.
Inspect the generator for loose or improper mounting and the generator drive belt for correct installation.
Inspect the drive belt for correct installation. Refer to Power Steering Pump Drive Belt Replacement in Power Steering Systems.

Intermittent

Faulty electrical connections or wiring may be the cause of intermittent conditions. Refer to Testing for Intermittent Conditions and Poor Connections in Wiring Systems.

Symptom List

Refer to a symptom diagnostic procedure from the following list in order to diagnose the symptom: