LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2005 >> Aveo Base, 4D Hatchback >> Repair and Diagnosis >> External Pages >> Different car >> Section 101 (Automatic Transaxle - AISIN 81-40LE - DTC P0562 To DTC P0742) >> DTC P0604 (Non European or N. American Emissions) >> Cause of Failure

Cause of Failure

WARNING: This page is about a different car, the 2008 Suzuki Swift +, 2008 Pontiac Wave, and 2008 Chevrolet Aveo. However, it is still accessible from the selected car via links, so may be relevant.
Step Action Yes No
1 Did you perform the Diagnostic System Check - Automatic Transmission? Go to Step 2  Go to Diagnostic System Check - Automatic Transmission
2
  1. Turn OFF the ignition.
  2. Install the scan tool.
  3. With the engine OFF, turn the ignition switch to the ON position.
  4. Select Store Freeze Frame/Failure Records from the DTC Information menu.
  5. Store Freeze Frame/Failure Records.
  6. Select Clear DTC Information from the DTC Information menu.
  7. Clear DTC Information.
  8. Perform 2 vehicle drive cycles.
Is the hold lamp ON?		 Go to Step 3  Go to Step 4 
3
  1. Select Request DTC by Status from the DTC Information menu.
  2. Request DTC by Status.
Is DTC P0604 displayed?		 Go to Step 5  Go to Step 4 
4 Inspect the transmission control module (TCM) wiring harness and connector for signs of an intermittent condition. Repair as necessary.
Did you complete the action?		 System OK -
5 Replace the TCM. Refer to Transmission Control Module Replacement .
Did you complete the replacement?		 System OK -
scientia non olet · About LEMON Manuals