LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Monte Carlo SS >> Repair and Diagnosis >> External Pages >> Different car >> Section 567 (Engine Mechanical - 3.4L V6 - VIN (E) (La1)) >> Repair Instructions >> Off-Vehicle Repair Instructions >> Oil Pump Installation

Oil Pump Installation

WARNING: This page is about a different car, the 2003 Chevrolet Monte Carlo and 2003 Chevrolet Impala. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: View Of Crankshaft Oil Deflector & Nuts
    GM187031Courtesy of GENERAL MOTORS CORP.
  1. Install the crankshaft oil deflector.
    2. NOTE: Refer to Fastener Notice in Cautions and Notices.
  2. Install the crankshaft oil deflector nuts.

    Tighten:  Tighten the crankshaft oil deflector nuts to 25 N.m (18 lb ft).

    3. Fig 2: Installing Oil Pump
    GM635915Courtesy of GENERAL MOTORS CORP.
    IMPORTANT: Do not reuse the oil pump driveshaft retainer. During assembly, install a NEW oil pump driveshaft retainer.
  3. Install the oil pump.
  4. Position the oil pump onto the pins.
  5. Install the oil pump bolt attaching the oil pump to the rear crankshaft bearing cap.

    Tighten:  Tighten the oil pump bolt to 41 N.m (30 lb ft).

scientia non olet · About LEMON Manuals