LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 981 (Battery, Charging System & Starting System) >> Repair Instructions >> Starter Motor Replacement (4.3L Engine) >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2004 GMC Sierra, 2004 GMC Cab & Chassis Sierra, 2004 Chevrolet Silverado, and 2004 Chevrolet Cab & Chassis Silverado. However, it is still accessible from the selected car via links, so may be relevant.
CAUTION: Refer to Battery Disconnect Caution in Cautions and Notices.
  1. Disconnect the negative battery cable. Refer to Battery Negative Cable Disconnect/Connect Procedure (Single Battery)  or Battery Negative Cable Disconnect/Connect Procedure (Auxiliary Battery) .
  2. Raise and suitably support the vehicle. Refer to Lifting and Jacking the Vehicle in General Information.
  3. Remove the starter motor bolts.
    4. Fig 1: View Of Starter Motor & Bolts (4.3L)
    GM7306Courtesy of GENERAL MOTORS CORP.
  4. Remove the starter lead nut (9).
  5. Remove the positive cable (1) from the starter.
    6. Fig 2: View Of Positive Battery Cable Fasteners
    GM785046Courtesy of GENERAL MOTORS CORP.
  6. Remove the starter solenoid nut.
  7. Remove the harness from the starter.
    8. Fig 3: View Of Starter Harness (4.3L)
    GM368413Courtesy of GENERAL MOTORS CORP.
  8. Remove the starter from the vehicle.
scientia non olet · About LEMON Manuals