LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 980 (Supplemental Inflatable Restraint System) >> Diagnostic Information and Procedures >> DTC 063: NA >> Diagnostic Aids

Diagnostic Aids

WARNING: This page is about a different car, the 2004 GMC Sierra, 2004 GMC Cab & Chassis Sierra, 2004 Chevrolet Silverado, and 2004 Chevrolet Cab & Chassis Silverado. However, it is still accessible from the selected car via links, so may be relevant.

The presence of current or history DTCs while attempting to rezero the PPS will cause the PPS module to set DTC 063. Verify that all SIR and PPS DTCs have been cleared before rezeroing the PPS.

DTC 063

Step Action Yes No
1 Did you perform the Diagnostic System Check - SIR? Go to Step 2  Go to Diagnostic System Check - SIR 
2
  1. Install a scan tool.
  2. Turn ON the ignition, with the engine OFF.
  3. Use the scan tool in order to clear the SIR and PPS DTCs.
  4. Rezero the PPS. Refer to Passenger Presence System Rezeroing Procedure .
  5. Operate the vehicle within the Conditions for Running the DTC as specified in the supporting text.
Does the DTC reset?		 Go to Step 3  Go to Diagnostic System Check - SIR 
3
IMPORTANT: The passenger presence system (PPS) is a calibrated system. The PPS must be rezeroed after replacement.
Replace the PPS. Refer to Inflatable Restraint Passenger Presence System Replacement - Front .Did you complete the replacement?		 Go to Step 4  -
4
  1. Reconnect all SIR and PPS system components.
  2. Verify that all components, connectors and CPAs are properly mounted.
  3. Use the scan tool in order to clear the SIR and PPS DTCs.
  4. Rezero the PPS. Refer to Passenger Presence System Rezeroing Procedure .
  5. Operate the vehicle within the Conditions for Running the DTC as specified in the supporting text.
Did you complete the repair?		 Go to Diagnostic System Check - SIR  -
scientia non olet · About LEMON Manuals