LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 955 (Door System, Mirror System & Window System) >> Repair Instructions >> Door Replacement - Rear >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2004 GMC Sierra, 2004 GMC Cab & Chassis Sierra, 2004 Chevrolet Silverado, and 2004 Chevrolet Cab & Chassis Silverado. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the door trim panel. Refer to Trim Panel Replacement - Side Rear Door (Crew Cab) .
  2. Remove the window. Refer to Module Replacement - Rear Power Window .
  3. Remove the inside door handle. Refer to Door Handle Replacement - Inside .
  4. Remove the outside door handle. Refer to Door Handle Replacement - Outside .
  5. Remove the door lock actuator. Refer to Lock Actuator Replacement - Rear Door .
  6. Remove the weatherstrip from the door. Refer to Weatherstrip Replacement - Rear Door .
  7. Disconnect the door wire harness. Refer to Wiring Harness Replacement - Door .
    8. Fig 1: Disconnecting Door Wire Harness
    GM581577Courtesy of GENERAL MOTORS CORP.
  8. Remove the door check link bolt from the pillar side.
  9. With an assistant, remove the bolts from the upper and the lower door hinges.
    10. Fig 2: Removing Door Upper & Lower Door Hinge Bolts
    GM522133Courtesy of GENERAL MOTORS CORP.
  10. With an assistant, lift the door up from the hinge pins and remove the door from the vehicle.
scientia non olet · About LEMON Manuals