LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 955 (Door System, Mirror System & Window System) >> Repair Instructions >> Door Replacement - Rear Side Access >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2004 GMC Sierra, 2004 GMC Cab & Chassis Sierra, 2004 Chevrolet Silverado, and 2004 Chevrolet Cab & Chassis Silverado. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the door trim panel. Refer to Trim Panel Replacement - Side Access Door .
  2. Remove the stationary window.
  3. Remove the inside door handle. Refer to Door Handle Replacement - Inside .
  4. Remove the outside door handle. Refer to Door Handle Replacement - Outside .
  5. Remove the upper and lower door latches. Refer to Latch Replacement - Side Door Upper  and Latch Replacement - Side Door Lower .
  6. Remove the door speaker.
  7. Remove the weatherstrip from the door. Refer to Weatherstrip Replacement - Side Door Opening .
  8. Disconnect the door wire harness. Refer to Wiring Harness Replacement - Door .
    9. Fig 1: Disconnecting Door Wire Harness
    GM581577Courtesy of GENERAL MOTORS CORP.
  9. Remove the front door striker. Refer to Striker Replacement - Door .
  10. Remove the door check link bolt from the pillar side.
  11. Remove the hinge retaining clips.
    12. Fig 2: Removing Hinge Retaining Clips
    GM522133Courtesy of GENERAL MOTORS CORP.
  12. With an assistant, lift the door up from the hinge pins and remove the door from the vehicle.
scientia non olet · About LEMON Manuals