LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 855 (Engine Mechanical - 4.8L, 5.3L & 6.0L) >> Repair Instructions >> Off-Vehicle Repair Instructions >> Exhaust Manifold Installation - Right

Exhaust Manifold Installation - Right

WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2003 GMC Yukon XL, 2003 GMC Yukon, 2003 Chevrolet Tahoe, 2003 Chevrolet Suburban, and 2003 Chevrolet Avalanche. However, it is still accessible from the selected car via links, so may be relevant.

Important: 

  1. Apply a 5 mm (0.2 in) wide band of threadlock GM P/N 12345493 (Canadian P/N 10953488) or equivalent to the threads of the exhaust manifold bolts. Refer to Sealers, Adhesives And Lubricants .
  2. Install the exhaust manifold gasket and exhaust manifold.
    NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  3. Install the exhaust manifold bolts.

    Tighten 

    1. 3.1. Tighten the exhaust manifold bolts first pass to 15 N.m (11 lb ft). Tighten the exhaust manifold bolts beginning with the center two bolts. Alternate from side-to-side, and work toward the outside bolts.
    2. 3.2. Tighten the exhaust manifold bolts final pass to 25 N.m (18 lb ft). Tighten the exhaust manifold bolts beginning with the center two bolts. Alternate from side-to-side, and work toward the outside bolts.
  4. Using a flat punch, bend over the exposed edge of the exhaust manifold gasket at the front of the right cylinder head.
    Fig 1: Installing Exhaust Manifold Gasket & Exhaust Manifold (Right)
    G02116997Courtesy of GENERAL MOTORS CORP.
  5. Install the heat shield (2) and bolts (3).

    Tighten 

    Tighten the heat shield bolts to 9 N.m (80 lb in).

    Fig 2: Installing Heat Shield & Bolts (Right)
    G02116998Courtesy of GENERAL MOTORS CORP.