LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 854 (Transfer Case - NVG 236/246-NP8) >> Repair Instructions >> Transfer Case Output Shaft Seal Replacement - Rear >> Installation Procedure

Installation Procedure

WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2003 GMC Yukon XL, 2003 GMC Yukon, 2003 Chevrolet Tahoe, 2003 Chevrolet Suburban, and 2003 Chevrolet Avalanche. However, it is still accessible from the selected car via links, so may be relevant.
  1. Using the J 45380  , install a NEW output shaft bushing.
    1. Install the bushing or the finger section of the J 45380  .
    2. Install the finger section to the main body of the J 45380  .
    3. Position the bushing and tool to the case.
    4. Using a hammer and the J 45380  , install the bushing.
    Fig 1: Installing Rear Output Shaft Bushing Using J 45380
    G01456641Courtesy of GENERAL MOTORS CORP.

    Important:  Ensure the drain hole on the boot of the rear output shaft seal is facing down toward the ground.

  2. Using the J 37668-A  , install a NEW front output shaft seal.
  3. Install the rear propeller shaft. Refer to  PROPELLER SHAFT REPLACEMENT -- REAR  in Propeller Shaft.
  4. Check the fluid level. Add fluid if necessary.
  5. Install the transfer case shield, if equipped. Refer to TRANSFER CASE SHIELD REPLACEMENT  .
    Fig 2: Installing Front Output Shaft Bushing Using J 37668-A
    G01456642Courtesy of GENERAL MOTORS CORP.