LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 725 (Door System, Mirror System & Window System) >> Repair Instructions >> Door Replacement - Front >> Removal Procedure

Removal Procedure

WARNING: This page does not describe the selected car, but rather 7 other vehicles, including the 2002 GMC Yukon XL, 2002 GMC Yukon, 2002 Chevrolet Tahoe, 2002 Chevrolet Suburban, and 2002 Chevrolet Avalanche. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the door trim panel. Refer to Trim Panel Replacement - Side Front Door .
  2. Remove mirror. Refer to Mirror Replacement (Power Mirror)  or Mirror Replacement (Manual) .
  3. Remove the window. Refer to Window Replacement - Front Door .
  4. Remove the window module. Refer to Module Replacement - Front Power Window .
  5. Remove the inside door handle. Refer to Door Handle Replacement - Inside .
  6. Remove the outside door handle. Refer to Door Handle Replacement - Outside .
  7. Remove the door lock actuator. Refer to Lock Actuator Replacement - Front Door .
  8. Remove the weatherstrip from the door. Refer to Weatherstrip Replacement - Front Door (Upper)  or Weatherstrip Replacement - Front Door (Door Opening) .
  9. Disconnect the door wire harness. Refer to Wiring Harness Replacement - Door .
    10. Fig 1: Door Upper & Lower Hinge Bolts
    GM348485Courtesy of GENERAL MOTORS CORP.
  10. Remove the door check link bolt from the pillar side.
  11. Remove the bolts from the upper door hinge and the lower door hinge.
  12. With an assistant, lift the door up from the hinge pins, and remove the door from the vehicle.
scientia non olet · About LEMON Manuals