LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 589 (Engine Mechanical - 2.2L) >> Removal And Installation >> In-Vehicle >> Balance Shaft Chain Replacement >> Removal

Balance Shaft Chain Replacement: Removal

WARNING: This page is about a different car, the 2003 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
  1. Disconnect negative battery cable.
  2. Remove timing chain assembly. Refer to TIMING CHAIN REPLACEMENT .
  3. Remove balance shaft drive chain tensioner bolts.
    Fig 1: Removing Balance Shaft Drive Chain Tensioner Bolts
    G01039149Courtesy of GENERAL MOTORS CORP.
  4. Remove balance shaft drive chain tensioner.
    Fig 2: Removing Balance Shaft Drive Chain Tensioner
    G01039150Courtesy of GENERAL MOTORS CORP.
  5. Remove adjustable balance shaft chain guide bolts.
  6. Remove adjustable balance shaft chain guide.
    Fig 3: Removing Adjustable Balance Shaft Chain Guide
    G01039151Courtesy of GENERAL MOTORS CORP.
  7. Remove small balance shaft chain guide bolts.
  8. Remove small balance shaft chain guide.
    Fig 4: Removing Small Balance Shaft Chain Guide
    G01039152Courtesy of GENERAL MOTORS CORP.
  9. Remove upper balance shaft chain guide bolts.
  10. Remove upper balance shaft chain guide.
    Fig 5: Removing Upper Balance Shaft Chain Guide
    G01039153Courtesy of GENERAL MOTORS CORP.

    IMPORTANT:  Push on chain between water pump and crankshaft sprockets so that all slack is between these two points. This will allow easier removal of chain.

  11. Remove balance shaft drive chain.
  12. Remove crankshaft drive sprocket.
    Fig 6: Removing Balance Shaft Drive Chain And Crankshaft Drive Sprocket
    G01039154Courtesy of GENERAL MOTORS CORP.
    NOTE: Replace balance shaft drive chain guide if wear exceeds 1.12 mm (0.045 in.)
  13. Inspect balance shaft drive chain guides for cracking or wear.
    NOTE: Replace balance shaft drive chain tensioner shoe if wear exceeds 1.12 mm (0.045 in.).
  14. Inspect balance shaft drive chain tensioner shoe for excessive wear.
  15. Inspect balance shaft drive chain and sprockets for wear sprocket and teeth for chips or damage to chain links.
    Fig 7: Inspecting Balance Shaft Drive Chain, Sprockets And Balance Shaft Drive Chain Tensioner Shoe
    G01039155Courtesy of GENERAL MOTORS CORP.